10开式循环冷却水泵控调试试验记录表TSC-10

Saudi Rabigh 2×660MW UNIT 1（660MW） SCS COMMISSIONING RECORD NO：TSC-10 CODE：YD.Rabigh.TS.RK /JL/FB/TSC10 工程名称 NAME 沙特Rabigh 2×660MW #1机 Saudi Rabigh 2×660MW UNIT 1 试运阶段 PHASE 分部试运 TRIAL-RUN 专业名称 PROFESSION 热控专业 I&C 项目名称 NAME 开式循环冷却水系统试验纪录表 ACW SYSTEM TEST RECORD NO. COMMISSIONING CONTENT RESULT REMARK 1 开式循环冷却水泵A 10PCB20AP001 ACW PUMP A YD.Rabigh.TS.RK /JL/FB/TSC10-001 2 开式循环冷却水泵B 10PCB10AP001 ACW PUMP B YD.Rabigh.TS.RK /JL/FB/TSC10-002 3 开式循环冷却水泵 A入口电动门 ACW PUMP A INLET MOV 10PCB14AA001 YD.Rabigh.TS.RK /JL/FB/TSC10-003 4 开式循环冷却水泵A出口电动门 ACW PUMP A OUTLET MOV 10PCB14AA002 YD.Rabigh.TS.RK /JL/FB/TSC10-004 5 开式循环冷却水泵 B入口电动门 ACW PUMP B INLET MOV 10PCB10AA003 YD.Rabigh.TS.RK /JL/FB/TSC10-005 6 开式循环冷却水泵B出口电动门 ACW PUMP B OUTLET MOV 10PCB10AA002 YD.Rabigh.TS.RK /JL/FB/TSC10-006 7 8 9 10 11 12 13 14 施工部门: 调试部门: 运行部门: SEPCOⅢ： COMMISSIONING： OPERATION： 开式循环冷却水泵系统试验表 ACW SYSTEM TEST RECORD NAME：ACW PUMP A CODE：YD.Rabigh.TS.RK /JL/FB/TSC10-001 NO. CONTENT RESULT REMARK TEST CONDITION a、运行人员对相关系统检查完成并正常 a、Operators have finished systems checking and the systmes is in normal operation b、DCS相关硬件、软件工作正常 b、DCS handwares and software are in normal operation 1 START PERMIT （AND） a、开式循环冷却水泵A轴承温度正常<90 a、Open Cycle Cooling Water Pump A Bearing Temp<90 b、开式循环冷却水泵A电机轴承温度正常<90 b、Open Cycle Cooling Water Pump A Motor Bearing Temp<90 c、开式循环冷却水泵A电机线圈温度正常<135 c、Open Cycle Cooling Water Pump A Motor Wind Temp<135 d、开式循环冷却水泵A入口电动门已开 d、Open Cycle Cooling Water Pump A Inlet Motor Butterfly Valve opened e、开式循环冷却水泵A出口电动门全关或泵投备用 e、Open Cycle Cooling Water Pump A Outlet Motor Butterfly Valve closed Or PUMP INTERLOCK INPUT f、A电动滤水器前后电动门全开或B电动滤水器前后电动门全开 f、Water system OK ，Inlet water side open(Motor Filter A Inlet/Outlet Motor Butterfly Valve open Or Motor Filter B Inlet/Outlet Motor Butterfly Valve open) 无跳闸条件 h、任一循环水泵运行 h、Any CWP Running 2 STOP PERMIT 连锁未投入OR 联启条件没来 3 INTERLOCK START (OR) 泵联锁投入且开式循环冷却水泵B运行且开式泵出口母管压力<0.12MPA，延时2秒 a、PUMP INTERLOCK INPUT AND ACW PUMP B RUNNING AND ACW PUMP OUTLET HEADER PRESS LOW<0.15MPA（DON 2s） b、泵联锁投入且开式循环冷却水泵B停运 b、PUMP INTERLOCK INPUT AND ACW PUMP B STOPPED 4 INTERLOCK STOP （OR） a、开式循环冷却水泵A轴承温度>95 a、Open Cycle Cooling Water Pump A Bearing Temp>95 b、开式循环冷却水泵A电机轴承温度>95 b、Open Cycle Cooling Water Pump A Motor Bearing Temp>95 c、开式循环冷却水泵A电机线圈温度>140 c、Open Cycle Cooling Water Pump A Motor Wind Temp>140 d、开式循环冷却水泵A运行延时3s 入口蝶阀关。 d、Open Cycle Cooling Water Pump A running, Inlet Hydraulic Butterfly Valve closed, with 3s delay e、开式循环冷却水泵A运行延时15s，出口蝶阀关 e、Open Cycle Cooling Water Pump A running with 15s delay, Outlet Hydraulic Butterfly Valve closed f、所有循环水泵停运延时2秒 f、All CWP Tripped DON 2 S 开式循环冷却水泵系统试验记录表 ACW SYSTEM TEST RECORD NAME：ACW PUMP B CODE：YD.Rabigh.TS.RK /JL/FB/TSC10-002 NO. CONTENT RESULT REMARK TEST CONDITION a、运行人员对相关系统检查完成并正常 a、Operators have finished systems checking and the systmes is in normal operation b、DCS相关硬件、软件工作正常 b、DCS handwares and software are in normal operation 1 START PERMIT （AND） a、开式循环冷却水泵B轴承温度正常<90 a、Open Cycle Cooling Water Pump B Bearing Temp<90 b、开式循环冷却水泵B电机轴承温度正常<90 b、Open Cycle Cooling Water Pump B Motor Bearing Temp<90 c、开式循环冷却水泵B电机线圈温度正常<135 c、Open Cycle Cooling Water Pump B Motor Wind Temp<135 d、开式循环冷却水泵B入口电动门已开 d、Open Cycle Cooling Water Pump B Inlet Motor Butterfly Valve opened e、开式循环冷却水泵B出口电动门全关或泵投备用 e、Open Cycle Cooling Water Pump B Outlet Motor Butterfly Valve closed Or PUMP INTERLOCK INPUT f、A电动滤水器前后电动门全开或B电动滤水器前后电动门全开 f、Water system OK ，Inlet water side open(Motor Filter A Inlet/Outlet Motor Butterfly Valve open Or Motor Filter B Inlet/Outlet Motor Butterfly Valve open) 无跳闸条件 h、任一循环水泵运行 h、Any CWP Running 2 STOP PERMIT 连锁未投入OR 联启条件没来 3 INTERLOCK START (OR) 泵联锁投入且开式循环冷却水泵A运行且开式泵出口母管压力<0.12MPA，延时2秒 a、PUMP INTERLOCK INPUT AND ACW PUMP A RUNNING AND ACW PUMP OUTLET HEADER PRESS LOW<0.15MPA（DON 2s） b、泵联锁投入且开式循环冷却水泵A停运 b、PUMP INTERLOCK INPUT AND ACW PUMP A STOPPED 4 INTERLOCK STOP （OR） a、开式循环冷却水泵B轴承温度>95 a、Open Cycle Cooling Water Pump B Bearing Temp>95 b、开式循环冷却水泵B电机轴承温度>95 b、Open Cycle Cooling Water Pump B Motor Bearing Temp>95 c、开式循环冷却水泵B电机线圈温度>140 c、Open Cycle Cooling Water Pump B Motor Wind Temp>140 d、开式循环冷却水泵B运行，延时3s，入口蝶阀关 d、Open Cycle Cooling Water Pump B running, Inlet Hydraulic Butterfly Valve closed, with 3s delay e、开式循环冷却水泵B运行延时15s，出口蝶阀关 e、Open Cycle Cooling Water Pump B running with 15s delay, Outlet Hydraulic Butterfly Valve closed f、所有循环水泵停运延时2秒 f、All CWP Tripped DON 2 S 开式循环冷却水泵系统试验记录表 ACW SYSTEM TEST RECORD NAME：ACW PUMP A INLET MOV CODE：YD.Rabigh.TS.RK /JL/FB/TSC10-003 NO. CONTENT RESULT REMARK TEST CONDITION a、运行人员对相关系统检查完成并正常 a、Operators have finished systems checking and the systmes is in normal operation b、DCS相关硬件、软件工作正常 b、DCS handwares and software are in normal operation 1 OPEN PERMIT 2 CLOSE PERMIT a、开式循环冷却水泵A停止 a、ACW PUMP A STOPPED 3 INERLOCK OPEN （OR） 开式循环冷却水泵A运行 a、ACW PUMP A RUNNING A泵联锁投入 b、ACW PUMP A INTERLOCK INPUT 4 INTERLOCK CLOSE 开式循环冷却水泵A跳闸 a、ACW PUMP A TRIPPED 开式循环冷却水泵系统试验记录表 ACW SYSTEM TEST RECORD NAME：ACW PUMP A OUTLET MOV CODE：YD.Rabigh.TS.RK /JL/FB/TSC10-004 NO. CONTENT RESULT REMARK TEST CONDITION a、运行人员对相关系统检查完成并正常 a、Operators have finished systems checking and the systmes is in normal operation b、DCS相关硬件、软件工作正常 b、DCS handwares and software are in normal operation 1 OPEN PERMIT 2 CLOSE PERMIT a、开式循环冷却水泵A停止 a、ACW PUMP A STOPPED 3 INERLOCK OPEN （OR） 开式循环冷却水泵A运行 a、ACW PUMP A RUNNING A泵联锁投入 b、ACW PUMP A INTERLOCK INPUT 4 INTERLOCK CLOSE 开式循环冷却水泵A跳闸 a、ACW PUMP A TRIPPED 开式循环冷却水泵系统试验记录表 ACW SYSTEM TEST RECORD NAME：ACW PUMP B INLET MOV CODE：YD.Rabigh.TS.RK /JL/FB/TSC10-005 NO. CONTENT RESULT REMARK TEST CONDITION a、运行人员对相关系统检查完成并正常 a、Operators have finished systems checking and the systmes is in normal operation b、DCS相关硬件、软件工作正常 b、DCS handwares and software are in normal operation 1 OPEN PERMIT 2 CLOSE PERMIT a、开式循环冷却水泵B停止 a、ACW PUMP B STOPPED 3 INERLOCK OPEN （OR） 开式循环冷却水泵B运行 a、ACW PUMP B RUNNING B泵联锁投入 b、ACW PUMP B INTERLOCK INPUT 4 INTERLOCK CLOSE 开式循环冷却水泵B跳闸 a、ACW PUMP B TRIPPED 开式循环冷却水泵系统试验记录表 ACW SYSTEM TEST RECORD NAME：ACW PUMP B OUTLET MOV CODE：YD.Rabigh.TS.RK /JL/FB/TSC10-006 NO. CONTENT RESULT REMARK TEST CONDITION a、运行人员对相关系统检查完成并正常 a、Operators have finished systems checking and the systmes is in normal operation b、DCS相关硬件、软件工作正常 b、DCS handwares and software are in normal operation 1 OPEN PERMIT 2 CLOSE PERMIT a、开式循环冷却水泵B停止 a、ACW PUMP B STOPPED 3 INERLOCK OPEN （OR） 开式循环冷却水泵B运行 a、ACW PUMP B RUNNING B泵联锁投入 b、ACW PUMP B INTERLOCK INPUT 4 INTERLOCK CLOSE 开式循环冷却水泵B跳闸 a、ACW PUMP B TRIPPED 9