氯化橡胶底漆
氯化橡胶漆设计用于喷漆施工,其用途包括:用于中度恶劣环境下的钢材保护涂料,内Intended 墙和天花板保护涂料,具有抗菌性和部分耐化学品性.可低温涂装。 Uses
An anti-corrosive paint for equipments above and below water, easily repaired, Suitable
用途 for application at low
temperature. Product
单罐装,氯化橡胶底漆
Description
One pack, chlorinated rubber primer
产品简介
Volume Solids 固体份 ?40% Product
Dry Film Thickness干膜厚度 35microns 35微米
2 Information Theoretical Coverage 理论涂布率 9m/Kg 9平方米/公斤
Practical Coverage 实际涂布率 Allow appropriate loss 允许适量损耗 产品数据
Mix Radio 混合比 One pack 单罐装
Method of Application 施工方法
Airless Spray 无空气喷涂 Recommended 推荐采用
Brush or Roller 涂刷或辊涂 Recommended 推荐采用 Application
Details
施工详述 Conventional Spray 传统喷涂 Not Recommended 不推荐使用
Thinner 稀释剂 氯化橡胶专用稀释剂
Cleaner 油漆设备清洗剂 氯化橡胶专用稀释剂
Pot Life 使用期 Not limit 不限制
Storage 贮存期 One year 一年
Touch Drying time Substrate Hard Dry Over coating Interval
Dry
覆涂间隔 干燥时间 硬干 Temperature
干 Mix最短 Max最长 底材温度 (h)
(h)
5? 8 hour 小时 2 24
7day (天) 25? 4 hour 小时 1 8
35? 2 hour 小时 0.5 8
Storage
Storage 贮存 Store in cool and dry conditions 贮存于阴凉干燥处
and Pack size 包装规格 25Kg in 20 liter container 25公斤装于20公升容
Handling 器中
Flash Point 闪点 ?23? 高于23? 贮存与管理
Specific Gravity 比重 Approx1.3Kg/L 大约1.3公斤/公升
Specification The surface to be applied must be clean, dry.
and
在施工前应保持表面清洁,干燥。
Surface
preparation
技术要求及表
面处理
The product must be used in painting area by professionals. When painting , please be
sure to refer to Product Data Sheet and MSDS. Consult our company if consumers
could not completely understand the precautions for safety and health when applying
the product.
The product is a kind of solvent-based paint. In order to avoid the accident or
dangerous occurrence, minimal safety precaution, as follow, should be down.
The paint contains volatile solvent and it is flammable, So must keep away from sparks
and open flames. No smoking at workplace, Effective precautions (such as using
explosion-proof electrical equipments. No static electricity accumulation or metal
collision etc) also should be done so as to avoid product sparks.
Enough ventilation is necessary at application sites. In order to remove any danger of 3explosion, must keep the ratio of gas / air is less than 10 %, Usually 200 mof
ventilation quantity per 1 Kg solvent (according to the solvent) is necessary, it canMaintain the minimum explosive limit. Take effective precautions to prevent skin
and eye contact with the coating (such as the use of overalls, gloves, goggles, face shields and protective oil coating and so on). If paint gets in touch with skin,If
accidental skin contact with the product, please use fresh water and soap or an
appropriate industrial cleaning agents thoroughly cleansed. In case of eyes being
contaminated, rinse with fresh water for 10 min at least and give medical treatment
immediately.During painting, it is recommended to wear face shields to prevent
inhalation of paint mist and harmful gases.Especially in poorly ventilated environment,
it is more necessary.Finally, be handled with care so as not to waste paint barrels of
pollution of the environment.
NOTICE: If consumers have not taken effective safety precautions (Refer to the
specification), our company will NOT be responsible for any accident.
Safety 本产品必须由专业人员在工业场所使用。使用时请务必参照本说明书以及相关
健康安全手册。若客户在使用本产品前,未能详细了解本产品的相关健康安全知识, Precautions 请与本公司人员联系。
安全措施 该涂料为溶剂型涂料,为避免事故或危险发生,应采取最低限度的安全措施如下:
此涂料为易燃物,并含有挥发性易燃溶剂,故必须远离火星和明火。
严禁在作业场所吸烟,并应该采取有效措施,防止火星产生(如采用防爆电器设备,
杜绝静电积累,避免金属撞击等)。
施工场所应尽量保持良好通风。为消除使用过程中的爆炸隐患,应保证足够的通风
量以维持气体/空气比例不超过最低爆炸极限的10 %,通常每千克溶剂需要200立
方米通风量,(与溶剂种类相关)就能维持最低爆炸极限10 %的工作环境。
采取有效措施,防止皮肤和眼睛与涂料直接接触(如使用工作服,手套,护目镜,面罩
及涂防护油等)。若皮肤不慎与产品相接触,请用清水及肥皂或适当的工业清洁剂
彻底清洗;若眼睛受到污染,请即刻用清水冲洗至少10分钟,并立即就医。
在施工时,建议佩戴面罩以免吸入漆雾和有害气体,尤其在通风不良的环境下,
更要注意。最后请谨慎处理废旧漆桶以免污染环境。
责任声明:对于未按本公司所要求采取有效得安全措施而引起的安全事故,本公
司不负任何责任。江苏纽克莱涂料有限公司